West Fraser lumber. File photo.

West Fraser lumber. File photo.

Worker buried in sawdust in a shavings bin at West Fraser B.C. Sawmill

WorksafeBC said rescue was needed on one occasion as the worker was unable to help themself

A worker at the Chasm Sawmill division of West Fraser was buried to about head or chest depth in a wood shavings bin area and needed to be rescued, according to a WorkSafeBC report.

“A worker performing clean up during maintenance type work inside a bin approximately 50 to 80 feet high, 30 feet wide, was engulfed by sawdust and/or wood shavings type recovery waste product,” according to the report. “The need for rescue did arise and the lone worker was engulfed and unable to self-rescue.”

The incident was not immediately reported to the board and between the time of the worker being buried and the conclusion of the full investigation, work resumed.

“This employer did not immediately undertake a preliminary investigation that identified all the unsafe conditions, acts or procedures as far as possible, in order to ensure that work can be continued or resumed,” according to the report. “Also, according to information provided by the employer, another worker was engulfed; however, that worker managed to self-rescue.”

The report notes that West Fraser failed to ensure adequate protection from entrapment or engulfment, a serious health and/or safety hazard.

The worker who entered the wood shavings recovery type bin, “was not provided with and did not wear a lifeline and harness, and was not continuously tended by a standby person who is equipped for and capable of effecting immediate rescue.”

WorkSafeBC was notified approximately one week later during a routine inspection, according to the report.

“This employer failed to ensure the scene of an accident that is reportable under subsection (1) was not disturbed, to permit investigate, and prevent potential injuries or death, and any other worker(s) being engulfed.”

A preliminary investigation report was completed and provided to a WorkSafeBC officer. West Fraser has since developed and performed a risk assessment, developed a safe work procedure for entering the shavings bin and as of Nov. 21 planned an emergency drill for confined space and/or enclosed space within the next 30 days.

Part of the actions includes no entry into the bin unless the material is four feet or less.

“A Vac truck and hose system will be used from outside the bin when materials are greater than four feet.”

The 100 Mile Free Press has contacted West Fraser but has not yet received a response.


newsroom@100milefreepress.net

Like us on Facebook and follow us on Twitter.

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

The Greater Nanaimo Chamber of Commerce has asked Nanaimo city council to consider a commercial property tax freeze to help offset negative financial impacts of COVID-19. (News Bulletin file photo)
Nanaimo council asks for report on potential one-year commercial property tax freeze

Report based on chamber of commerce proposal to ease COVID-19 stress on business community

Literacy Central Vancouver Island’s IPALS program – parents as literacy supporters in immigrant communities – recently secured another five years of funding from senior levels of government. (Photo submitted)
Literacy program working for immigrant families in Nanaimo

Literacy Central Vancouver Island’s IPALS program sees funding extended another five years

Nanaimo Ladysmith Public Schools is preparing a rapid response team proposal for submission to the B.C. Ministry of Education. (Chris Bush/News Bulletin)
Nanaimo-Ladysmith school district chosen to field COVID-19 rapid response team

Team to consist of SD68 and Island Health staff, according to B.C. Ministry of Education

A 50-year-old man was stabbed in an altercation that started with a disagreement about physical distancing. (File photo)
Argument about physical distancing leads to stabbing in Nanaimo

Suspect arrested on Gabriola Island an hour after incident Wednesday, Feb. 24

The Gabriola Environmentally Responsible Trans-Island Express fleet will be able to move to a new depot facility after receiving more than $187,000 of community economic recovery infrastructure program money from the Province of B.C. (Submitted photo)
Gabriola bus system receives $188,000 from province for depot building

Old fire hall to be retrofitted and serve as new bus terminal thanks to COVID-19 recovery funding

Provincial health officer Dr. Bonnie Henry updates B.C.’s COVID-19 situation at the B.C. legislature. (B.C. government)
B.C. reports 10 additional deaths, 395 new COVID-19 cases

The majority of new coronavirus infections were in the Fraser Health region

Canada approves use of AstraZeneca’s COVID-19 vaccine

The country joins more than a dozen other countries that have given the shot the green light

A new survey has found that virtual visits are British Columbian’s preferred way to see the doctor amid the COVID-19 pandemic. (Unsplash)
Majority of British Columbians now prefer routine virtual doctor’s visits: study

More than 82% feel virtual health options reduce wait times, 64% think they lead to better health

Carolyn Howe, a kindergarten teacher and vice president of the Greater Victoria Teachers’ Association, says educators are feeling the strain of the COVID-19 pandemic and the influx of pressure that comes with it. (Nina Grossman/News Staff)
Stress leave, tears and insomnia: Island teachers feel the strain of COVID-19

Teachers still adjusting to mask and cleaning rules, pressures from outside and within

Ella Donovan with mom Tina outside Fuller Lake Arena before heading onto the ice for practice. (Photo by Don Bodger)
Young Ladysmith skater watches and waits in battle against cancer

Ella Donovan’s tumour began a tumultuous time, but community support eased the burden

Captain and Maria, a pair of big and affectionate akbash dogs, must be adopted together because they are so closely bonded. (SPCA image)
Shuswap SPCA seeks forever home for inseparable Akbash dogs

A fundraiser to help medical expenses for Captain and Maria earned over 10 times its goal

The missing camper heard a GSAR helicopter, and ran from his tree well waving his arms. File photo
Man trapped on Manning mountain did nearly everything right to survive: SAR

The winter experienced camper was overwhelmed by snow conditions

Cory Mills, Eric Blackmore and A.J. Jensen, all 20, drown in the Sooke River in February 2020. (Contributed photos)
Coroner confirms ‘puddle jumping’ in 2020 drowning deaths of 3 B.C. men

Cory Mills, Eric Blackmore and A.J. Jensen pulled into raging river driving through nearby flooding

Castlegar doctor Megan Taylor contracted COVID-19 in November. This photo was taken before the pandemic. Photo: Submitted
Kootenay doctor shares experience contracting COVID-19

Castlegar doctor shares her COVID experience

Most Read