Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Plans to distribute 1st doses of the Johnson & Johnson COVID-19 vaccine on hold

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility

Plans to distribute the first 300,000 doses of the Johnson & Johnson COVID-19 vaccine next week are on hold after Health Canada learned part of them were manufactured at a Maryland facility that messed up the ingredients in 15 million doses bound for the U.S. market.

The Emergent Biosolutions facility in Baltimore was recently cited by the U.S. Food and Drug Administration for violations including cleaning and sterilization failures, the potential for cross-contamination and failure to follow required protocols.

The FDA ordered the facility to stop making more J&J vaccine until the problems are corrected and the earlier mistake on the doses resulted in all 15 million being destroyed.

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility, but did not think the Canadian J&J doses had any connection to that plant.

Now Health Canada says the drug substance that makes up part of the J&J vaccine was actually produced there and then shipped elsewhere for the vaccines to be finished.

Health Canada says it is seeking information from the FDA and J&J’s pharmaceutical arm, Janssen, to determine if the 300,000 doses shipped to Canada meet required safety standards.

“As with all vaccines imported into Canada, the Janssen vaccines will only be released for distribution once Health Canada is satisfied that they meet the Department’s high standards for quality, safety and efficacy,” Health Canada said Friday evening in a release.

“Health Canada has rigorous processes in place to continually monitor the quality of vaccines that are administered to Canadians.

“We will continue to ensure that products coming from the Emergent facility, or any other facility, will only be imported and distributed in Canada if they are of high quality and safe for use.”

Until Friday, Health Canada had refused to say where Canada’s doses had been made, citing fear of disrupting a confidential supply chain.

The J&J vaccine has not been used in Canada so far, and the National Advisory Committee on Immunization hasn’t yet provided guidance on how they think it should be used.

The doses arrived in Canada on Wednesday and are in holding at the Innomar Strategies facility near Toronto’s Pearson airport. Innomar is contracted to receive and redistribute all vaccines in Canada, except Pfizer-BioNTech. That vaccine is shipped directly to provincial governments.

The Canadian Press

Like us on Facebook and follow us on Twitter.

Want to support local journalism? Make a donation here.

Coronavirus

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

Nanaimo Ladysmith Public Schools’ superintendent Scott Saywell at a May 6 press event for two new electric school buses. (Karl Yu/News Bulletin)
Nanaimo-Ladysmith school district shows off electric buses

New buses anticipated to reduce 17 tonnes of greenhouse gas emissions from SD68 buses

A B.C. Centre for Disease Control map showing new COVID-19 cases by local health area for the week of April 25-May 1. (BCCDC image)
Vancouver Island’s COVID-19 case counts trending down

Fewer than 200 active cases on the Island, down from highs of 500-plus earlier this spring

Nanaimo city council has voted to deploy speed-reduction measures for the summer along Departure Bay Road and to consult with area residents and road users to explore ways to further reduce vehicle speeds in the Departure Bay Beach area. (News Bulletin file photo)
City will again lower speed limit on Departure Bay Road to 40km/h

City of Nanaimo will consult with stakeholders for ideas to reduce speeds past the beach

Reforming food systems will require taking a long view, and determined people organizing at tipping points, says columnist. (Stock photo)
OPINION: Food system reform can change world for the better

‘Long food movement’ could be a road map to curb our current global follies, says columnist

Traffic service worker Warren Van Sickle installs street banners bearing cedar bough designs by artist Becky Thiessen outside the Nanaimo Ice Centre on May 5. (Josef Jacobson/The News Bulletin)
City of Nanaimo installs new street banners envisioning ecological survival

Artist Becky Thiessen’s designs depict cedar boughs and the Nanaimo estuary

Beef to the woman focused on her phone, driving a dark-coloured sedan through the Cilaire school zone. Perhaps you could use that same device to research some of the accidents and injuries caused by drivers who can’t seem to stay off their phones whilst behind the wheel.
Beefs & Bouquets, May 5

To submit a beef or a bouquet to the Nanaimo News Bulletin, e-mail editor@nanaimobulletin.com

Two semi trucks collided on the Nanaimo Parkway just north of Northfield Road on Wednesday morning, May 5. (Chris Bush/News Bulletin)
UPDATE: Nanaimo Parkway reopens after crash involving semi trucks

35-year-old driver was taken to hospital with serious injuries

The Canadian Coast Guard icebreaker Louis S. St-Laurent sails past a iceberg in Lancaster Sound, Friday, July 11, 2008. The federal government is expected to end nearly two years of mystery today and reveal its plan to build a new, long overdue heavy icebreaker for the Canadian Coast Guard. THE CANADIAN PRESS/Jonathan Hayward
Vancouver, Quebec shipyards to each get new heavy icebreaker, cost remains a mystery

Vancouver’s Seaspan Shipyards and Quebec-based Chantier Davie will each build an icebreaker for the coast guard

Findings indicate a culture of racism, misogyny and bullying has gripped the game with 64 per cent of people involved saying players bully others outside of the rink. (Pixabay)
Misogyny, racism and bullying prevalent across Canadian youth hockey, survey finds

56% of youth hockey players and coaches say disrespect to women is a problem in Canada’s sport

People line up outside an immunization clinic to get their Oxford-AstraZeneca COVID-19 vaccine in Edmonton, Tuesday, April 20, 2021. THE CANADIAN PRESS/Jason Franson
Hospital investigating whether Alberta woman who died after AstraZeneca shot was turned away

Woman was taken off life support 12 days after getting vaccine

People line up for COVID-19 vaccination at a drop-in clinic at Cloverdale Recreation Centre on Wednesday, April 27, 2021. Public health officials have focused efforts on the Fraser Health region. (Aaron Hinks/Peace Arch News)
B.C.’s COVID-19 spread continues with 694 new cases Thursday

Two million vaccine doses reached, hospital cases down

Allayah Yoli Thomas had recently turned 12 years old when she died of a suspected drug overdose April 15. (Courtesy of Adriana Londono)
Suspected overdose death of Vancouver Island 12 year old speaks to lack of supports

Allayah Yoli Thomas was found dead by her friend the morning of April 15

More than 6,000 camping reservations in British Columbia were cancelled as a result of a provincial order limiting travel between health regions. (Unsplash)
1 in 4 camping reservations cancelled in B.C. amid COVID-19 travel restrictions

More than 6,500 BC Parks campsite reservations for between April 19 and May 25 have been revoked

B.C. average home price and sales level to 2023, showing steep drop in sales expected next year. (Central 1)
Forecast calls for B.C. home sales to ‘explode,’ then drop off

Average price to rise another 10% in 2021, credit unions say

Most Read